This will assist your selecting accessories such as a ball mount, bike rack or cargo carrier. Had past experience with travel trailer weight. Please review the vehicle options and installation notes, to ensure you select the correct product for your Toyota Highlander. Did you install it yourself? Note: The vehicle occupants, cargo, and any added equipment count against the max towing capacity, so be careful. Now with all of our fasteners in place we'll go ahead and tighten them down then torque to specifications as indicated in the instructions. To do that we'll use our paint marker to mark the area and a drummel to cut out the section. To begin our install we'll first need to remove the underbody trim panels.
This is what our hitch will look like once its installed. Listed below are the Trailer Hitches that are designed to work with the 2013 Toyota Highlander. We had to purchase a tap and die set to recut the threads in the frame of the vehicle. This is deceit on behalf of Toyota. With 750 pounds tongue weight and 5,000 pounds towing weight capacity, our hidden hitch will give your Toyota the ability to have a remarkable ride allow you to explore every possibility. Now with all our cut outs made we can go ahead and reinstall the underbody panel.
This is limited by the 2. Installation is pretty much plug and play with 6 bolts and some trimming of the under panel. They also have a 200W fan coupling i. The problem with towing such trailers is their shape and poor aerodynamic conditions, in addition their taking over the control of the driving experience ie. I tried to use a chisle to get it out but that only rounded the piece over. Hitch Cross tube Is Visible Beneath Bumper.
Having the standard towing features, heavy duty radiator, oil cooler, trans cooler, heavy duty battery, etc, we did all the research to find that we could tow 500 lbs hitch, 5,000 lbs total. Needed die grinder with cut-off wheel to complete install, a tool not always available to average consumer. It took longer than the time stat. The engine has more than enough power though, just concerned about the rear suspension and the vehicle carrying that load for a few weeks during the move. Beyond that, however, things improve dramatically… Note: As of , all 6-cylinder Highlanders have the tow prep package and a 5,000 lb towing capacity. Now let's go ahead with the installation. The Toyota hitch is the bomb.
The hitch is secured with 10 x 12mm bolts — probably twice what aftermarket hitches use. My question is, does it fit? The third will prevent a clear metal to metal contact between the hitch and the frame. Please click this link for more details. Before we begin our install, here's what the hitch looks like when it's installed on the vehicle. There'll be three on the driver's side and four here on the passenger side; two on the side of the frame and two in the bottom of the frame. That sounds relatively easy and is something that I could do myself.
We were told by an expert that our 4,200 lb travel trailer would burn up the Highlanders transmission and engine as the rpms were very high when driving the rig 60 mph. Aside from the gas mileage hit and quick unexpected stops I easily forget that I am towing the trailer. Even the most liberal of sources will recommend adding the stated cargo capacity of the trailer to the unloaded weight for towing planning. If you think you're having this problem, you can quickly verify if your hitch is bent through careful visual inspection. Same goes with the case of a severely bent hitch.
Found a solution on etrailer. Here on the driver's side to remove the underbody panel there are a total of six fasteners, two push pin fasteners and four screws. That would put your example at 6000+lbs easily with the above example and I am not surprise it was too much for the Highlander. Now with our cut made we'll go ahead and remove the bolt that secured it to the frame. We tried to trade it to another dealer for a smaller travel trailer but was told that the only trailer that our front wheel drive Highlander should pull should be a pop-up camper being very light weight.
When I picked up the special ordered trailer a month later, driving home dropped my gas mileage from 28 mpg down to 8 mpg, without even any cargo! Check every component that's connected to your hitch and make sure they're all fitted snugly. Once we remove the fasteners we'll set the hardware and tow hooks aside as they will not be reinstalled. The vehicle is certified to tow up to 5000 lbs. After having the best Curt hitch installed professionally, I found that Toyota had made no pre wires for electric brakes. Great customer service and fast shipping. From the center of the hitch pin hole to the outermost edge of the bumper is one inch. Thank you for putting the installation instructions online.
But you can also save a ton of money by ordering the parts and installing them yourself. We'll install each fastener finger tight until we have them all in place. I went to install my bike rack and found a chunk of weld inside. The 30 Amp circuit is always powered so that the lights work with the engine turned off. Look out for deformed areas. If you already know what you want, simply order online and we'll ship it to your front door. Need assistance selecting the right Draw-Tite product? Some embellishment to add emphasis is ok, but fabricating to Hollywood levels is not.
If I add the tow hitch and wiring harness, what else do I need to do, if anything, to ensure I take advantage of the full 5000 lbs tow capacity? Hitch was exceptionally well designed and instructions very good — I used a pair of aviation shears to cut the parts off the two under-corner plastic covers that needed to be modified per the Toyota instructions — no real problems. I asked at the dealer and was told that installing additional wiring and a brake controller in the vehicle voids all Toyota warranties. Then, bolt it to your crossover in under an hour, using tools from our handy Loan-a-Tool program. All V6 Highlanders comes with the Tow Package standard besides the tow hitch. Trailer Hitches - Draw-Tite 24847 Rating: 3 Stars Shipping was fast and I was very happy with the whole transaction. Note, many V6 Toyota Highlanders have the towing prep package even though it is not listed as having such.